Professional ac repair services for homes and businesses in Pilot Point and surrounding Texas communities.
Air conditioning systems serving Pilot Point, TX homes operate under demanding conditions, and KIC Refrigeration provides the repair expertise needed to keep your cooling running at full capacity. From refrigerant recharging and compressor replacement to contactor repair and condenser fan motor service, our technicians resolve every AC fault with verified, measured results.
Properties throughout Pilot Point (pop. 7,948) face unique demands when it comes to ac repair. Texas heating loads, cooling calculations, and the insulation levels and duct configurations found in Pilot Point homes all influence the approach we take. KIC Refrigeration tailors every ac repair project to the conditions your property actually faces — no generic solutions.
Choosing the right contractor for ac repair in Pilot Point, TX makes all the difference between efficient comfort and a system that short-cycles. KIC Refrigeration uses Manual J load calculations, installs to manufacturer specifications, and backs every project with a warranty. Call (866) 858-2961 to schedule your free assessment.
From initial contact to final verification — here is how we handle ac repair.
We assess your air conditioning problem — no cooling, weak airflow, strange noises, ice buildup, or short cycling — and perform a safety check on electrical connections, circuit breaker, disconnect, and thermostat wiring before beginning hands-on diagnostics.
At your Pilot Point property, our technician tests the run and start capacitors with a capacitance meter, checks the contactor for pitting and voltage drop, measures compressor amperage against rated load amps, and reads suction and discharge pressures to calculate superheat and subcooling against the manufacturer charge chart for current conditions.
KIC Refrigeration performs AC repairs in Pilot Point, TX by the book. For electrical failures, we match the replacement part to factory specifications. For sealed-system repairs, we follow EPA Section 608 recovery procedures, braze with nitrogen purge, pressure test to 300 PSI, evacuate to 500 microns, and charge by weight — never by guessing or topping off.
We run the system for a minimum of 15 minutes, measure the temperature split across the evaporator coil (target: 16 to 22 degrees), verify suction and discharge pressures, check condenser fan and blower motor amperage, and confirm the thermostat cycles the system off at setpoint.
Transparent answers about ac repair from our certified technicians.
AC repair in Pilot Point typically costs $150 to $500 for common component failures including run capacitors ($150 to $250), contactors ($150 to $350), condenser fan motors ($250 to $500), and blower motors ($300 to $600). Compressor replacement is the most expensive repair at $1,500 to $3,500 depending on unit tonnage and whether the system uses R-410A or older R-22 refrigerant. Evaporator coil replacement runs $800 to $2,500 including the refrigerant recovery and recharge. KIC Refrigeration provides a detailed written estimate with itemized parts and labor costs before beginning any AC repair at your Pilot Point property so there are no surprises on the invoice.
Most AC repairs in Pilot Point are completed in 1 to 2 hours during a single service visit. Capacitor and contactor replacements are quick fixes that take 15 to 30 minutes of hands-on time. Fan motor and blower motor replacements take 1 to 2 hours including wiring and testing. Compressor replacement is the most time-intensive repair at 3 to 6 hours because it requires refrigerant recovery with an EPA-certified machine, compressor removal, new compressor installation, nitrogen-purged brazing, pressure testing at 300 PSI, evacuation to below 500 microns, and recharging by weight. KIC Refrigeration arrives at your Pilot Point home with a fully stocked truck to complete most repairs in a single visit.
An AC that runs but produces little or no cooling is most commonly caused by low refrigerant charge from a leak, which reduces the suction pressure and causes the evaporator coil temperature to drop below 32 degrees, forming ice that blocks airflow completely. Other causes include a dirty condenser coil that cannot reject heat, a failed compressor that runs but does not pump refrigerant, a stuck or failed metering device — either a TXV or fixed orifice — that restricts refrigerant flow, or a blower motor running at reduced speed due to a failing capacitor. KIC Refrigeration connects manifold gauges at your Pilot Point home and measures suction pressure, discharge pressure, superheat, and subcooling to diagnose the exact cause.
KIC Refrigeration repairs every major air conditioning brand installed in Pilot Point homes and commercial properties — Carrier, Trane, Lennox, Rheem, Goodman, Daikin, York, Bryant, Amana, Ruud, Heil, and all other manufacturers. Our technicians hold EPA Section 608 Universal certification for refrigerant handling and are trained to work with R-410A, R-22, R-32, R-454B, and all other regulated refrigerants found in residential and light commercial systems. Whether your AC is a 2-ton window package unit or a 5-ton split system, a 20-year-old R-22 unit or a brand-new inverter model, KIC Refrigeration has the diagnostic capability and parts access to repair it correctly at your Pilot Point property.
Our reputation is built on certified technicians, honest pricing, and results that last.
"Our mini split stopped cooling mid-summer and they fit us in the next morning. Diagnosed a bad capacitor, replaced it on the spot. Back to normal in under an hour."
"AC tune-up before summer. Technician was early, finished in about forty-five minutes, and gave me a clean bill of health on the system. Easy process."
"Mini split repair was done right the first time. The outdoor unit had a refrigerant leak and they found it, fixed it, and recharged the system same day."